struts replaced, lights no longer self-level |
Post Reply |
Author | |
RickB
MINI Motorer Joined: May/20/05 Location: Shoreline, WA Status: Offline Points: 226 |
Post Options
Thanks(0)
Posted: March/16/15 at 9:57pm |
Apparently, there's a sensor for the self-leveling headlights on the left-rear, upper suspension control arm; likely it could be deranged while installing new struts? The lights are now aimed uselessly low, and don't flash up and down when initially turned-on. |
|
'02 Cooper S, Alta pulley, Alta CAI, M7 brace, Madness brace, One-ball, D1 Spec Throttle Controller, ExtremeContact DW, Koni FSD, Boot Box, Glove Box Organizer . . .
Diligentia, Vis, Celeritas |
|
RickB
MINI Motorer Joined: May/20/05 Location: Shoreline, WA Status: Offline Points: 226 |
Post Options
Thanks(0)
|
Can someone respond with at least a, "Geez, that sucks"?
|
|
'02 Cooper S, Alta pulley, Alta CAI, M7 brace, Madness brace, One-ball, D1 Spec Throttle Controller, ExtremeContact DW, Koni FSD, Boot Box, Glove Box Organizer . . .
Diligentia, Vis, Celeritas |
|
CINIMIN
MINI Motorer Joined: August/27/05 Location: Everett WA Status: Offline Points: 4676 |
Post Options
Thanks(0)
|
I have no direct experience with this problem - only thing I might suggest is a visit to North American Motoring - the national MINI club / forums. http://www.northamericanmotoring.com/ And you are right - it sucks that no one has responded... |
|
Jack -
<font color=RED>CINIMIN [/COLOR] 2006 CR/W MCS - 6spd - LSD -15% Pulley - Dinan CAI ASA JH6's Koni FSD's 22mm Bar Have you hugged a curve today? |
|
Rob N
PSMINI Expert Advisor PSMINI Member Joined: August/13/04 Location: United States Status: Offline Points: 2020 |
Post Options
Thanks(0)
|
It is on the Drivers side lower front control arm as I recall. A little lever with some wires that sits on top of the arm. Measures the angle.
|
|
Rob, Vickie and Alice
COOPR-S The question is, "When you turn on your car does it return the favor?" |
|
Rob N
PSMINI Expert Advisor PSMINI Member Joined: August/13/04 Location: United States Status: Offline Points: 2020 |
Post Options
Thanks(0)
|
If they removed the control arm for any reason, the sensor had to be removed.
|
|
Rob, Vickie and Alice
COOPR-S The question is, "When you turn on your car does it return the favor?" |
|
Rob N
PSMINI Expert Advisor PSMINI Member Joined: August/13/04 Location: United States Status: Offline Points: 2020 |
Post Options
Thanks(0)
|
Looking at pelican parts, apparently there is one in the rear too. Who knew. Probably should check them both out and make sure they are attached and wiring connected. |
|
Rob, Vickie and Alice
COOPR-S The question is, "When you turn on your car does it return the favor?" |
|
Rob N
PSMINI Expert Advisor PSMINI Member Joined: August/13/04 Location: United States Status: Offline Points: 2020 |
Post Options
Thanks(0)
|
I have the Bentley for this car if you need to look at it. I'm in Mill Creek.
|
|
Rob, Vickie and Alice
COOPR-S The question is, "When you turn on your car does it return the favor?" |
|
scoopieb
MINI Motorer PSMINI Nonmember Joined: December/18/09 Location: Kent, wa Status: Offline Points: 110 |
Post Options
Thanks(0)
|
sorry, been off for a few days. Yes, there is a self leveling switch and bracket on the driver side lower rca. When I put on my new rca, I ended up using some hose clamps to hold the bracket on. Eventually, I'll drill the control arm and attach with screws. It's worked fine now for about 6K miles. It's not pretty but it works. If you want I can take a picture tomorrow and put it up. |
|
06 MCS RMW BVH, Street cam, RCA, coolant tank & Tune/Dinan CAI/Alta 15%V2/Dinan exhaust & ST/OS Giken GT/Carbon fiber/MOMO/BC coilover/swift
|
|
RickB
MINI Motorer Joined: May/20/05 Location: Shoreline, WA Status: Offline Points: 226 |
Post Options
Thanks(0)
|
Sorry, if the "can't someone at least" comment sounded snarky. I was feeling a bit frustrated with my situation, and looking for some company in my misery. Spent $2000 on new struts and tires, excited about how the car would drive, and what do I get but a leaky tire and broken headlights. The headlight sensor had not been perfectly reinstalled, and was a five-minute fix. The leaky tire was a bent wheel, and after getting a $200-if-it-doesn't-crack estimate, it cost $90 at another shop. The car drives nicely, all four tires are holding air, and I can see where I'm going at night! |
|
'02 Cooper S, Alta pulley, Alta CAI, M7 brace, Madness brace, One-ball, D1 Spec Throttle Controller, ExtremeContact DW, Koni FSD, Boot Box, Glove Box Organizer . . .
Diligentia, Vis, Celeritas |
|
CINIMIN
MINI Motorer Joined: August/27/05 Location: Everett WA Status: Offline Points: 4676 |
Post Options
Thanks(0)
|
Life is good - especially in a fully functional MINI! Thanks for posting the follow up. |
|
Jack -
<font color=RED>CINIMIN [/COLOR] 2006 CR/W MCS - 6spd - LSD -15% Pulley - Dinan CAI ASA JH6's Koni FSD's 22mm Bar Have you hugged a curve today? |
|
Post Reply | |
Tweet |
Forum Jump | Forum Permissions You cannot post new topics in this forum You cannot reply to topics in this forum You cannot delete your posts in this forum You cannot edit your posts in this forum You cannot create polls in this forum You cannot vote in polls in this forum |